为了探讨冰淇淋等冷冻甜品溶液的流变性对冷冻成品中冰晶生长的影响,配制0.3%(质量分数)的不同亲水胶体(黄原胶、罗望子胶、瓜尔豆胶、羧甲基纤维素和刺槐豆胶)的糖溶液,通过依次降低糖溶液中0%、15%、30%、45%、60%和75%的水含量模拟冷品冷冻过程,分别采用流变和低温显微镜技术研究溶液的黏弹性与重结晶速率的关系。结果表明,与不含亲水胶体的对照组比较,含不同亲水胶体的糖溶液的流变性对重结晶速率具有显著性影响,其中,罗望子胶对重结晶速率影响最为显著,使得重结晶速率从对照组的62.45 μm3/h减小为1.66 μm3/h;糖溶液的标准化断点黏度与标准化断点模量均和重结晶速率具有良好的线性相关性,相关系数分别为r2=0.92和r2=0.95。以上结果表明在冷冻浓缩过程中,糖溶液的流变性与其冰晶生长有关,添加亲水胶体可降低糖溶液的重结晶速率,延缓冰晶生长,并可借此预测和判断冰的重结晶速率,为工业生产节约成本。该研究为亲水胶体,尤其是罗望子胶降低重结晶速率、控制冰晶大小以及提高冷冻甜品感官品质的应用奠定理论依据。
张幸运
,
钟秋婵
,
王树欣
,
易祖欣
,
王欣语
,
李明轩
,
王光强
,
宋子波
,
艾连中
,
张汇
. 亲水胶体对糖溶液模拟冷冻过程中冰晶生长的影响[J]. 食品与发酵工业, 2020
, 46(22)
: 21
-27
.
DOI: 10.13995/j.cnki.11-1802/ts.024856
To investigate the effect of rheological properties of frozen dessert solutions such as ice cream on the growth of ice crystals in frozen products,sugar solutions containing 0.3% (w/w) of different hydrocolloids (xanthan gum,tamarind seed gum,guar gum,carboxymethylcellulose and locust bean gum,respectively) were prepared.The water content of sugar solutions were sequentially reduced by 0%,15%,30%,45%,60% and 75% to simulate the freezing process.The effects of viscoelasticity of solutions on the rate of recrystallization were studied using rheology and cryomicroscopy techniques.Results showed that the rheology of sugar solutions supplemented with different hydrocolloids had significant effects on the recrystallization rate by comparing with control group without hydrocolloid.And the tamarind seed gum reduced the recrystallization rate from 62.45 μm3/h of control group to 1.66 μm3/h which exhibiting the most significant effect among all the samples.Both standardized breakpoints of viscosity and modulus of sugar solution presented good linear correlations with the rate of recrystallization (correlation coefficients of r2=0.92 and r2=0.95,respectively).Above results indicated that the rheological properties of sugar solutions with hydrocolloids during freezing process were related to the growth of ice crystals.Supplementation of viscous hydrocolloids could reduce the rate of recrystallization,delay ice crystal growth,and predict and judge the ice recrystallization rate,and thus saving costs for industrial production.This study established a theoretical foundation for the application of hydrocolloid,especially tamarind seed gum,on reducing recrystallization rate,controlling ice crystal size and improving sensory quality of frozen desserts.
[1] 苏蕾.糖醇对冰晶大小的影响及在冰淇淋中的应用[D].天津:天津商业大学,2017.
[2] LIVNEY T W,HARTEL R W.Ice recrystallization in ice cream:Interactions between sweeteners and stabilizers[J].Journal of Dairy Science,1997,80(3):447-456.
[3] HARTEL R W.Ice crystallization during the manufacture of ice cream[J].Trends in Food Science &Technology,1996,7(10):315-321.
[4] HARPER E K,SHOEMAKER C F.Effects of locust beam gum and selected sweetening agents on ice recrystallization rates[J].Food Science,1983,48(6):1 801-1 803.
[5] WITTINGER S A,SMITH D E.Effect of sweeteners/stabilize interactions on the viscosity and freezing point of ice cream mix[J].Milchwissenschaft,1986,41(12):766-769.
[6] HARTEL R W,SCHWARTZBERG H G.Physical Chemistry of Foods[M].New York:Marcel-Dekker,Inc,1992:47.
[7] SMITH C E,SCHWARTZBERG H G.Ice crystal size changes during ripening in freeze concentration[J].Biotechnology Progress,1985,1(2):111-120.
[8] ADAPA S,SCHMIDT K A,JEON I J,et al.Mechanisms of ice crystallization and recrystallization in ice cream:A review[J].Food Review International,2000,16(3):259-271.
[9] HAGIWARA T,HARTEL R W.Effect of sweetener,stabilizer and storage temperature on ice recrystallization in ice cream[J].Journal of Dairy Science,1996,79(5):735-744.
[10] DONHOWE D P,HARTEL R W.Recrystallization of ice in ice cream during controlled accelerated storage[J].International Dairy Journal,1996,6(11-12):1 191-1 208.
[11] LEVINE H,SLADE L.Polymer physico-chemical approach to the study of commercial starch hydrolysis products[J].Carbohydrate Polymers,1986,6(3):213-244.
[12] BUDIAMAN E R,FENNEMA O.Linear rate of water crystallization as influenced by viscosity of hydrocolloid suspensions[J].Dairy Science,1987,70(3):547-554.
[13] MUHR A H,BLANSHARD J M V.Effect of polysaccharide stabilizers on the rate of growth of ice[J].Food Technology,1986,21(6):683-710.
[14] BLOND G.Velocity of linear crystallization of ice in macromolecular systems[J].Cryobiology,1988,25(1):61-66.
[15] CALDWELL K B,GOFF H D,STANLEY D W.A low temperature scanning electron microscopy study of ice-cream.II.Influence of selected ingredients and processes[J].Food Structure,1992,11(1):11-23.
[16] GOFF H D,CALDWELL K B,STANLEY D W,et al.The influence of polysaccharides on the glass transition in frozen sucrose solutions and ice cream[J].Journal of Dairy Science,1993,76(5):1 268-1 277.
[17] BOLLIGER S,WILDMOSER H,GOFF H D,et al.Relationships between ice cream mix viscoelasticity and ice crystal growth in ice cream[J].International Dairy Journal,2000,10(11):791-797.
[18] GOFF H D,FRESLON B,SAHAGIAN M E,et al.Structural development in ice cream-dynamic rheological measurements[J].Texture Studies,1995,26(5):517-536.
[19] RODD A B,DUNSTAN D E,BOGER D V.Characterisation of xanthan gum solutions using dynamic light scattering and rheology[J].Carbohydrate Polymers,2000,42(2):159-174.
[20] 陈珍珍.微晶纤维素在冰淇淋中的应用[D].天津:天津商业大学,2014.
[21] 张宁.青稞麦仁β-葡聚糖的U结构,流变特性及对淀粉消化和葡萄糖扩散的影响[D].上海:上海理工大学,2018.
[22] 赖翠霞.大米粉团流变特性的研究[D].福州:福建农林大学,2012.
[23] RODD A B,DUNSTAN D E,BOGER D V.Characterisation of xanthan gum solutions using dynamic light scattering and rheology[J].Carbohydrate Polymers,2000,42(2):159-174.
[24] YING Q C,CHU B J M.Overlap concentration of macromolecules in solution[J].Macromolecules,1987,20(2):362-366.
[25] HAGIWARA T,HARTEL R W,MATSUKAWA S.Relationship between recrystallization rate of ice crystals in sugar solutions and water mobility in freeze-concentrated matrix[J].Food Biophysics,2006,1(2):74-82.
[26] 孙利军.新型冷饮稳定剂-罗望子胶的性质及应用[C].第十四届中国国际食品添加剂和配料展览会暨第二十届全国食品添加剂生产应用技术展示会.上海:中国食品添加剂,2010:252-257.
[27] BAHRAMPARVAR M,TEHRANI M M.Application and functions of stabilizers in ice cream[J].Food Reviews International,2011,27(4):389-407.
