在发酵工业中,性能优良的反应器能够起到增加产量和提高能量利用效率的作用。新研发的带有螺旋筛板的新型气升式反应器(airlift reactor with helical sieve plate,ALR-HSP),已经在空气-水实验中证实了其优良的传质特性。为研究反应器综合性能,选取2种具有代表性的真菌(高山被孢霉和毕赤酵母)在ALR-HSP中进行通风培养,分析发酵过程参数和产物组成并与经典气升式反应器(conventional airlift reactor,CALR)进行比较。结果显示：在高山被孢霉培养中,ALR-HSP内菌体的对数生长期的最大比生长速率较CALR提高30%,发酵结束后脂肪酸总量提高约40%;毕赤酵母培养中,ALR-HSP内菌体对数生长期的最大比生长速率较CALR提高20%,发酵结束后菌体浓度增长约20%。且在低通风量条件下,达到相同kLa,ALR-HSP的功率消耗比CALR减少50%。显示出螺旋筛板气升式反应器在耗氧生物培养过程中的优越传质特性和节能效益。
High-performance reactors play an important role in increasing yield and energy efficiency in fermentation industries. A novel airlift reactor with helical sieve plate (ALR-HSP) developed in our laboratory had proven its excellent mass transfer characteristics in air-water system. To validate its comprehensive performance,two typical fungi (Mortierella alpine and Pichia pastoris) were selected and cultivated in ALR-HSP comparison to that of conventional airlift reactor (CALR). In the cultivation of M. alpine,the maximal specific growth rate during the logarithmic growth phase of ALR-HSP were 30% higher than that of CALR,and the total fatty acid increased by about 40% under the same culture conditions. ,The maximum specific growth rate of P. pastoris during the logarithmic growth phase of ALR-HSP was 20% higher than that of CALR,and the concentration of biomass increased by about 20%. Under the condition of low gas flow rate,the power consumption of ALR-HSP was only about half of CALR when the same kLa was reached. These data show that the ALR-HSP had superior mass transfer characteristics and power saving performance during the process of aerobic biological cultivation.
[1] 郑志永,陈瑜琦,詹晓北,等. 一种带螺旋多孔筛板的气升式反应器:中国,201610956295.9[P].2016-10-28.
[2] MERCHUK J C,GLUZ M.Bioreactors,airlift reactors[M]. New Jersey: John Wiley and Sons,Inc., 2002.
[3] ZHENG Z,CHEN Y,ZHAN X,et al.Mass transfer intensification in a novel airlift reactor assembly with helical sieve plates[J]. Chemical Engineering Journal,2018,342:61-70.
[4] STREEKSTRA H.On the safety of Mortierella alpine for the production of food ingredients,such as arachidonic acid[J]. Journal of Biotechnology,1997,56(3):153-165.
[5] 王鸿超,张陈,周昕,等. 高山被孢霉GDP-L-岩藻糖合成途径中GDP-甘露糖-4,6-脱水酶的克隆、表达和功能鉴定[J].食品与发酵工业,2016,42(11):14-19.
[6] 王成,郑志永,朱莉,等. 通气量对气升式反应器培养高山被孢霉生产花生四烯酸的影响[J]. 生物加工过程,2015(1):68-74.
[7] CARNICER M,BAUMANN K,TÖPLITZ I,et al. Macromolecular and elemental composition analysis and extracellular metabolite balances of Pichia pastoris growing at different oxygen levels[J]. Microbial Cell Factories,2009,8:65-79.
[8] 许黎明,成春燕,韦星明,等. 大豆β-淀粉酶基因在毕赤酵母中的高密度发酵表达[J]. 食品与发酵工业,2017,43(9):32-37.
[9] TERVASMKI P,LATVA-KOKKO M,TASKILA S,et al.Mass transfer,gas hold-up and cell cultivation studies in a bottom agitated draft tube reactor and multiple impeller Rushton turbine configuration[J]. Chemical Engineering Science,2016,155:83-98.
[10] 熊鹏. 重组毕赤酵母发酵产甘露聚糖酶的工艺条件优化[D]. 武汉:中南民族大学,2018.
[11] 顾晓颖,王文思,陈家,等. 高产花生四烯酸的高山被孢霉菌株发酵条件优化[J]. 西南农业学报,2018,31(11):87-93.
[12] 陈瑜琦. 螺旋筛板式气升式反应器的传质特性及其初步应用[D]. 无锡:江南大学,2018.
[13] 杜祎,张金玲,朱思荣,等. 复合酶膜生物传感器差分法检测牛乳中乳糖的含量[J]. 山东科学,2019,32(6):43-48.
[14] Weatherburn M W.Phenol-hypochlorite reaction for determination of ammonia[J]. Analytical Chemistry,1967,39(8):971-974.
[15] 杨华,陈海琴,郝光飞,等.肉毒碱脂酰转移酶基因沉默对高山被孢霉脂质积累的影响[J]. 食品与发酵工业,2016,42(8):13-18.
[16] 王晓鹏. 高山被孢霉合成花生四烯酸油脂的调控研究[D]. 武汉:华中科技大学,2017.
[17] INAN M,MEAGHER M M.The effect of ethanol and acetate on protein expression in Pichia pastoris[J]. Journal Bioscience Bioengineering,2001,92(4):337-341.
[18] GARCIA-ORTEGA X,FERRER P,MONTESINOS JL,et al.Fed-batch operational strategies for recombinant Fab production with Pichia pastoris using the constitutive GAP promoter[J]. Biochemical Engineering Journal,2013,79:172-181.
[19] VILLADSEN J,NIELSEN J,LIDÉN G. Bioreaction engineering principles[M]. 3th ed. New York,Palo Alto: Springer,2011.
[20] 张静,赵建新,陈海琴,等. 高山被孢霉发酵生产多不饱和脂肪酸的初步研究[J]. 食品工业科技,2011,32(11):216-219.
[21] THOMAS K,RUTTER A,SULLER M,et al.Oxygen induces fatty acid (n-6)-desaturation independently of temperature in Acanthamoeba castellanii[J]. FEBS Letters,1998,425(1):171-174.
[22] LUO L,LIU F,XU Y,et al.Hydrodynamics and mass transfer characteristics in an internal loop airlift reactor with different spargers[J]. Chemical Engineering Journal,2011,175:494-504.
[23] GARCIA-OCHOA F,GOMEZ E.Bioreactor scale-up and oxygen transfer rate in microbial processes: an overview[J]. Biotechnology Advance,2009,27(2):153-176.
[24] BENZ GT.Optimize power consumption in aerobic fermenters[J]. Chemical Engineering Progress,2003,99(5):32-35.
[25] STOCKS S M,COOKE M,HEGGS P J.Inverted hollow spinning cone as a device for controlling foam and hold-up in pilot scale gassed agitated fermentation vessels[J]. Chemical Engineering Science,2005,60(8):2 231-223 8.
[26] HUANG L,DENG S,CHEN Z,et al.Numerical analysis of a novel gas-liquid pre-separation cyclone[J]. Separation and Purification Technology,2018,194:470-479.
