研究报告

中聚合度异麦芽/麦芽多糖的酶法合成和助溶效果研究

  • 薛乃祥 ,
  • 王艳丽 ,
  • 董晶晶 ,
  • 柏玉香
展开
  • 1(江南大学 食品科学与技术国家重点实验室,江苏 无锡,214122)
    2(江南大学 食品学院,江苏 无锡,214122)
    3(江南大学 食品安全与营养协同创新中心,江苏 无锡,214122)
第一作者:硕士研究生(柏玉香副研究员为通信作者,E-mail:ybai@jiangnan.edu.cn)

收稿日期: 2021-02-08

  修回日期: 2021-02-23

  网络出版日期: 2022-08-03

基金资助

江苏省优秀青年基金项目(BK20211581);国家自然科学基金面上项目(32072268)

Enzymatic synthesis and solubilization effect of megalo isomalto/malto-polysaccharides

  • XUE Naixiang ,
  • WANG Yanli ,
  • DONG Jingjing ,
  • BAI Yuxiang
Expand
  • 1(State Key Laboratory of Food Science and Technology, Jiangnan University, Wuxi 214122, China)
    2(School of Food Science and Technology, Jiangnan University, Wuxi 214122, China)
    3(Synergetic Innovation Center of Food Safety and Nutrition, Jiangnan University, Wuxi 214122, China)

Received date: 2021-02-08

  Revised date: 2021-02-23

  Online published: 2022-08-03

摘要

中聚合度异麦芽/麦芽多糖(megalo isomalto/malto-polysaccharides,M-IMMPs)在不阻碍低溶解度的乙基红生物降解的前提下展现出了新颖的助溶效果,但是其聚合度低(11~12),助溶效果弱,限制了M-IMMPs的研究和应用。该研究通过控制直链糊精和麦芽糖配比合成了一系列具有梯度分子质量的M-IMMPs,通过全波长扫描、核磁共振光谱、扫描电镜和傅里叶红外光谱对其乙基红助溶效果和复合物进行表征。结果表明,M-IMMPs分子质量越大,助溶效果越好,可使乙基红溶解度提高至4.5倍,且助溶效果并不仅来源于高分子质量和α1→6键含量。乙基红质子化学位移表明,疏水相互作用贡献了助溶效果。扫描电镜展示了原颗粒从片块、菱状向糊状的转变,红外光谱表明了存在氢键的可能。由于疏水相互作用的非特异性,M-IMMPs在其他偶氮染料中具有助溶应用潜力。

本文引用格式

薛乃祥 , 王艳丽 , 董晶晶 , 柏玉香 . 中聚合度异麦芽/麦芽多糖的酶法合成和助溶效果研究[J]. 食品与发酵工业, 2022 , 48(13) : 141 -147 . DOI: 10.13995/j.cnki.11-1802/ts.031101

Abstract

Megalo isomalto/malto-polysaccharides (M-IMMPs) exhibited a novel solubilization effect without hindering biodegradation of low-solubility ethyl red. However, the low degree of polymerization (11-12) and weak solubilization effect limit the research and application of M-IMMPs. A series of M-IMMPs (3.6-12.5 kDa) with a gradient molecular weight were synthesized by controlling the ratio of linear dextrins and maltose. The solubilization effect of M-IMMPs on ethyl red and the complex were characterized. The results showed that the higher the molecular weight of M-IMMPs, the better the solubilizing effect, which can increase the solubility of ethyl red to 4.5 times, and the solubilizing effect was not solely derived from the high molecular weight and the content of α1→6 linkage. The proton chemical shifts of ethyl red indicated that hydrophobic interaction contributed to the solubilizing effect. The co-existence of α1→6 and α1→4 linkages facilitated the formation of amphiphilic surfaces, enabling the formation of complex. There was a saturation effect for the hydrophobic interaction, it did not increase continuously with the addition of M-IMMPs. Scanning electron microscope showed the transformation of the original particles from flakes, rhombic to pasty, which confirmed the formation of the complex. The characteristic peak of —OH in Fourier transform infrared shifted from 3 311 cm-1 to 3 264 cm-1, which indicated the possibility of hydrogen bonding. M-IMMPs have potential application as a solubilizer in other azo dyes due to the non-specificity of the hydrophobic interaction.

参考文献

[1] 柏玉香, 吴浩.γ-环糊精工业化生产的研究进展[J].食品与发酵工业, 2021, 47(22):279-287.
BAI Y X, WU H.Research progress in industrial production of γ-cyclodextrin[J].Food and Fermentation Industries, 2021, 47(22):279-287.
[2] 任敏, 孙希阳, 贺丰洋, 等.β-环糊精包合物的研究进展[J].山东化工, 2020, 49(18):77-78.
REN M, SUN X Y, HE F Y, et al.Research progress of β-cyclodextrin inclusion complex[J].Shandong Chemical Industry, 2020, 49(18):77-78.
[3] TAKEDA S, NISHIMURA T, UMEZAKI K, et al.Synthesis and function of amphiphilic glucan dendrimers as nanocarriers for protein delivery[J].Biomaterials Science, 2019, 7(4):1 617-1 622.
[4] SHI Y N, YE F, LU K Y, et al.Characterizations and bioavailability of dendrimer-like glucan nanoparticulate system containing resveratrol[J].Journal of Agricultural and Food Chemistry, 2020, 68(23):6 420-6 429.
[5] OBIRO W C, SINHA RAY S, EMMAMBUX M N.V-amylose structural characteristics, methods of preparation, significance, and potential applications[J].Food Reviews International, 2012, 28(4):412-438.
[6] LIU J L, BAI Y X, JI H Y, et al.Controlling the fine structure of glycogen-like glucan by rational enzymatic synthesis[J].Journal of Agricultural and Food Chemistry, 2021, 69(49):14 951-14 960.
[7] JOE G H, ANDOH M, SHINOKI A, et al.Megalo-type α-1, 6-glucosaccharides induce production of tumor necrosis factor α in primary macrophages via toll-like receptor 4 signaling[J].Biomedical Research, 2016, 37(3):179-186.
[8] LEEMHUIS H, DIJKMAN W P, DOBRUCHOWSKA J M, et al.4, 6-α-Glucanotransferase activity occurs more widespread in Lactobacillus strains and constitutes a separate GH70 subfamily[J].Applied Microbiology and Biotechnology, 2013, 97(1):181-193.
[9] LANG W, KUMAGAI Y, SADAHIRO J, et al.Different molecular complexity of linear-isomaltomegalosaccharides and β-cyclodextrin on enhancing solubility of azo dye ethyl red:Towards dye biodegradation[J].Bioresource Technology, 2014, 169:518-524.
[10] 陈萌萌. 芳香胺异构体的同时定量分析研究[D].杭州:杭州师范大学, 2018.
CHEN M M.Simultaneous quantitative analysis of aromatic amine isomers[D].Hangzhou:Hangzhou Normal University, 2018.
[11] RUFCHAHI E O M, GILANI A G, TAGHVAEI V, et al.Synthesis, structural elucidation, solvatochromism and spectroscopic properties of some azo dyes derived from 6-chloro-4-hydroxyquinoline-2(1H)-one[J].Journal of Molecular Structure, 2016, 1108:623-630.
[12] JI Q Y, LIU G F, ZHOU J T, et al.Removal of water-insoluble Sudan dyes by Shewanella oneidensis MR-1[J].Bioresource Technology, 2012, 114:144-148.
[13] GEORGIOU D, METALLINOU C, AIVASIDIS A, et al.Decolorization of azo-reactive dyes and cotton-textile wastewater using anaerobic digestion and acetate-consuming bacteria[J].Biochemical Engineering Journal, 2004, 19(1):75-79.
[14] ZHAO L D, SUN Q M, PU H Y, et al.Experimental and computer simulation investigations of ethyl red with modified β-cyclodextrins:Inclusion mechanism and structure characterization[J].Chemical Physics Letters, 2020, 754:137725.
[15] HARA H, KUME S, IIZUKA T, et al.Enzymatically synthesized megalo-type isomaltosaccharides enhance the barrier function of the tight junction in the intestinal epithelium[J].Bioscience, Biotechnology, and Biochemistry, 2018, 82(4):629-635.
[16] BAI Y X, VAN DER KAAIJ R M, LEEMHUIS H, et al.Biochemical characterization of the Lactobacillus reuteri glycoside hydrolase family 70 GTFB type of 4, 6-α-glucanotransferase enzymes that synthesize soluble dietary starch fibers[J].Applied and Environmental Microbiology, 2015, 81(20):7 223-7 232.
[17] GU F J, BOREWICZ K, RICHTER B, et al.In vitro fermentation behavior of isomalto/malto-polysaccharides using human fecal inoculum indicates prebiotic potential[J].Molecular Nutrition & Food Research, 2018, 62(12):1800232.
[18] LANG W, SIRISANSANEEYAKUL S, NGIWSARA L, et al.Characterization of a new oxygen-insensitive azoreductase from Brevibacillus laterosporus TISTR1911:Toward dye decolorization using a packed-bed metal affinity reactor[J].Bioresource Technology, 2013, 150:298-306.
[19] VAN DER ZAAL P H, SCHOLS H A, BITTER J H, et al.Isomalto/malto-polysaccharide structure in relation to the structural properties of starch substrates[J].Carbohydrate Polymers, 2018, 185:179-186.
[20] DOBRUCHOWSKA J M, GERWIG G J, KRALJ S, et al.Structural characterization of linear isomalto-/ malto-oligomer products synthesized by the novel GTFB 4, 6-α-glucanotransferase enzyme from Lactobacillus reuteri 121[J].Glycobiology, 2011, 22(4):517-528.
[21] XUE N X, SVENSSON B, BAI Y X.Structure, function and enzymatic synthesis of glucosaccharides assembled mainly by α1 → 6 linkages: A review[J].Carbohydrate Polymers, 2022, 275:118705.
[22] VAN DER ZAAL P H, KLOSTERMANN C E, SCHOLS H A, et al.Enzymatic fingerprinting of isomalto/malto-polysaccharides[J].Carbohydrate Polymers, 2019, 205:279-286.
[23] NASONGKLA N, WIEDMANN A F, BRUENING A, et al.Enhancement of solubility and bioavailability of β-lapachone using cyclodextrin inclusion complexes[J].Pharmaceutical Research, 2003, 20(10):1 626-1 633.
[24] CHEN F, HUANG G L, HUANG H L.Preparation and application of dextran and its derivatives as carriers[J].International Journal of Biological Macromolecules, 2020, 145:827-834.
[25] SUNDARI C S, RAMAN B, BALASUBRAMANIAN D.Hydrophobic surfaces in oligosaccharides:Linear dextrims are amphiphilic chains[J].Biochimica et Biophysica Acta (BBA) - Biomembranes, 1991, 1065(1):35-41.
[26] SHINOKI A, LANG W, THAWORNKUNO C, et al.A novel mechanism for the promotion of quercetin glycoside absorption by megalo α-1, 6-glucosaccharide in the rat small intestine[J].Food Chemistry, 2013, 136(2):293-296.
[27] GAFNI A, COHEN Y.Complexes of macrocycles with γ-cyclodextrin as deduced from NMR diffusion measurements[J].The Journal of Organic Chemistry, 1997, 62(1):120-125.
[28] LIU K, ZHA X Q, SHEN W D, et al.The hydrogel of whey protein isolate coated by lotus root amylopectin enhance the stability and bioavailability of quercetin[J].Carbohydrate Polymers, 2020, 236:116009.
文章导航

/