食品与发酵工业 >

2022 , Vol. 48 >Issue 16: 131 - 137

DOI: https://doi.org/10.13995/j.cnki.11-1802/ts.028852

研究报告

基于低场核磁共振及成像技术的油莎豆远红外干燥过程中水分变化规律

  • 余政毫 ,
  • 朱文学 ,
  • 白喜婷 ,
  • 罗磊 ,
  • 卫志娇
展开
  • 1(河南科技大学 食品与生物工程学院,河南 洛阳,471023)
    2(农产品干燥技术与装备河南省工程技术研究中心,河南 洛阳,471023)
硕士研究生(朱文学教授为通信作者,E-mail:zhuwenxue67@126.com)

收稿日期: 2021-08-04

  修回日期: 2021-10-13

  网络出版日期: 2022-09-16

基金资助

国家重点研发计划项目(SQ2019YFD100114)

收起

Rule of water changes in the far-infrared drying of tiger nut based on low-field NMR and imaging technology

  • YU Zhenghao ,
  • ZHU Wenxue ,
  • BAI Xiting ,
  • LUO Lei ,
  • WEI Zhijiao
Expand
  • 1(College of Food and Bioengineering, Henan University of Science and Technology, Luoyang 471023, China)
    2(Agricultural Product Drying Technology and Equipment of Henan Engineering Technology Research Center, Luoyang 471023, China)

Received date: 2021-08-04

  Revised date: 2021-10-13

  Online published: 2022-09-16

Fold

摘要

为研究油莎豆远红外干燥过程中水分分布状态与迁移变化规律,利用低场核磁共振技术和成像技术检测不同温度(50、60、70 ℃)下远红外干燥过程中的横向驰豫时间,分析峰面积A2x的变化、磁共振成像(magnetic resonance imaging,MRI)图像的变化以及干燥前后微观结构变化。结果表明,在红外干燥过程中,温度为50、60、70 ℃时干燥至终点分别用时为450、360、260 min,随着温度的升高能够显著提高干燥速率,促进其内部的自由水、不易流动水和结合水的迁移。干燥过程中自由水逐渐减少外观发生收缩形变表皮皱缩,自由度高的水分向自由度低的迁移导致弛豫图向左迁移。水分总峰面积与干基含水率进行回归分析,得到R2分别为0.989 03、0.991 34、0.990 46,回归线性方程具有较高的拟合度。通过MRI图像可以清晰地看到红色面积逐渐缩小,油莎豆内部水分分布状态不断变化。干燥前后油莎豆微观结构变化明显,轮廓模糊、淀粉堆积。该研究可以为油莎豆的远红外干燥工艺设计、水分分布情况及水分状态变化提供参考。

关键词： 油莎豆; 水分迁移; 横向弛豫时间; 低场核磁共振成像技术; 低场核磁共振技术; 微观结构

本文引用格式

余政毫 , 朱文学 , 白喜婷 , 罗磊 , 卫志娇 . 基于低场核磁共振及成像技术的油莎豆远红外干燥过程中水分变化规律[J]. 食品与发酵工业, 2022 , 48(16) : 131 -137 . DOI: 10.13995/j.cnki.11-1802/ts.028852

Abstract

To study the law of water distribution and migration changes of tiger nut in the far-infrared drying process, low-field nuclear magnetic resonance technology (nuclear magnetic resonance, NMR) and imaging techniques were used to detect transverse relaxation time and T2 time in far-infrared drying at different temperatures (50, 60, 70 ℃). The changes of peak area A2x, MRI images and micro structural changed before and after drying were also been analyzed. It was shown that during infrared drying, when the temperature were 50, 60, and 70 ℃, the corresponding drying time were 450, 360, and 260 minutes. With the increase of temperature, the drying rate could be significantly increased and can promote the migration of free water, bound water and combined water. During drying, free water gradually reduced the appearance, and the migration of water with high degrees of freedom to low degrees of freedom leads to the relaxation diagram migration to the left. The total water peak area and dry base moisture content were analyzed, and R2 was 0.989 03, 0.991 34 and 0.990 46 respectively. The red area gradually shrinked in the MRI image, and the water distribution state of the tiger nut was constantly changed. Moreover, the microstructure of the oil bean was obvious which with a fuzzy outline and starch accumulation. This study can provide a reference for the far-infrared drying process design, water distribution and water status of the tiger nut.

Key words： tiger nut; water migration; lateral relaxation time; low-field MRI imaging technology; low field MRI; micro structural

参考文献

[1] 王瑞元, 王晓松, 相海.一种多用途的新兴油料作物—油莎豆[J].中国油脂, 2019, 44(1):1-4.
WANG R Y, WANG X S, XIANG H.A multi-purpose emerging oil crop—Cyperus beans[J].China Oils and Fats, 2019, 44(1):1-4.
[2] ALJUHAIMI, FAHAD, GHAFOOR, et al.The effect of solvent type and roasting processes on physico-chemical properties of tigernut (Cyperus esculentus L.) tuber oil[J].Journal of Oleo Science, 2018, 67(7):823-828.
[3] 陈星, 陈滴, 刘蕾.油莎豆全成分分析[J].食品科技, 2009, 34(3):165-168.
CHEN X, CHEN D, LIU L.Cyperus esculentus whole component analysis[J].Food Science and Technology, 2009, 34(3):165-168.
[4] 魏忠彩, 孙传祝, 张丽丽, 等.红外干燥技术在果蔬和粮食加工中的应用[J].食品与机械, 2016, 32(1):217-220.
WEI Z C, SUN C Z, ZHANG L L, et al.Progress of infrared drying technology applied in processing of fruits and vegetables and grain[J].Food and Machinery, 2016, 32(1):217-220.
[5] 宋平, 彭宇飞, 王桂红, 等.玉米种子萌发过程内部水分流动规律的低场核磁共振检测[J].农业工程学报, 2018, 34(10):274-281.
SONG P, PENG Y F, WANG G H, et al.Detection of internal water flow in germinating corn seeds based on low field nuclear magnetic resonance[J].Transactions of the Chinese Society of Agricultural Engineering, 2018, 34(10):274-281.
[6] KAMAL T, SONG Y, TAN Z, et al.Effect of hot-air oven dehydration process on water dynamics and microstructure of apple (Fuji) cultivar slices assessed by LF-NMR and MRI[J].Drying Technology, 2019, 37(15):1 974-1 987.
[7] SUN Q, ZHANG M, YANG P Q.Combination of LF-NMR and BP-ANN to monitor water states of typical fruits and vegetables during microwave vacuum drying[J].LWT, 2019, 116:108548.
[8] 曾雅, 刘云宏, 张嘉怡, 等.远红外辐射温度对猕猴桃干燥水分迁移的影响[J].食品与机械, 2019, 35(8):143-147.
ZENG Y, LIU Y H, ZHANG J Y, et al.Effects of far-infrared radiation temperature on the moisture transfer of kiwifruit slices[J].Food and Machinery, 2019, 35(8):143-147.
[9] 渠琛玲, 汪紫薇, 王雪珂, 等.基于低场核磁共振的热风干燥过程花生仁含水率预测模型[J].农业工程学报, 2019, 35(12):290-296.
QU C L, WANG Z W, WANG X K, et al.Prediction model of moisture in peanut kernel during hot air drying based on LF-NMR technology[J].Journal of Agricultural Engineering, 2019, 35(12):290-296.
[10] 段文娟, 李月, 崔莉, 等.低场核磁共振及成像技术分析白芍炮制过程中水分变化规律[J].中国中药杂志, 2017, 42(11):2 092-2 096.
DUAN W J, LI Y, CUI L, et al.Analyze moisture transformation and transport rules during processing of Paeoniae radix Alba by using low-field NMR[J].Chinese Journal of Traditional Chinese Medicine, 2017, 42(11):2 092-2 096.
[11] 周四晴, 段续, 任广跃, 等.厚度控制对怀山药远红外干燥过程中水分迁移的影响[J].食品与机械, 2019(12):75-81.
ZHOU S Q, DUAN X, REN G Y, et al.Effect of thickness on moisture transfer during far-infrared drying of Dioscorea opposite[J].Food and Machinery, 2019(12):75-81.
[12] 李潮锐, 刘青, 杨培强.鲜花生的低场核磁共振横向弛豫分析[J].中山大学学报(自然科学版), 2014(2):1-5.
LI C R, LIU Q, YANG P Q.Low field NMR transverse relaxation spectrum of peanut[J].Acta Scientiarum Naturalium Universitatis Sunyatseni, 2014(2):1-5.
[13] 张绪坤, 祝树森, 黄俭花, 等.用低场核磁分析胡萝卜切片干燥过程的内部水分变化[J].农业工程学报, 2012, 28(22):282-287.
ZHANG X K, ZHU S S, HUANG J H, et al.Analysis on internal moisture changes of carrot slices during drying process using low-field NMR[J].Transactions of the Chinese Society of Agricultural Engineering, 2012, 28(22):282-287.
[14] MONTEIRO MARQUES J P, RUTLEDGE D N, DUCAUZE C J.Low resolution pulse nuclear magnetic resonance study of water equilibration in dried carrots[J].International Journal of Food Science & Technology, 1991, 26(2):173-183.
[15] 李然, 李振川, 陈珊珊, 等.应用低场核磁共振研究绿豆浸泡过程[J].食品科学, 2009, 30(15):137-141.
LI R, LI Z C, CHEN S S, et al.Study of water absorption of mung beans based on low-field nuclear magnetic resonance technology[J].Food Science, 2009, 30(15):137-141.
[16] HANSEN C L, THYBO A K, BERTRAM H C, et al.Determination of dry matter content in potato tubers by low-field nuclear magnetic resonance (LF-NMR)[J].Journal of Agricultural and Food Chemistry, 2010, 58(19):10 300-10 304.
[17] 宋平, 徐静, 马贺男, 等.用低场核磁共振检测水稻浸种过程中种子水分的相态及分布特征[J].农业工程学报, 2016, 32(6):204-210.
SONG P, XU J, MA H N, et al.Moisture phase state and distribution characteristics of seed during rice seed soaking process by low field nuclear magnetic resonance[J].Transactions of the Chinese Society of Agricultural Engineering, 2016, 32(6):204-210.
[18] 付晓记, 唐爱清, 闵华, 等.花生浸种过程中水分相态和水分迁移动态研究[J].中国油料作物学报, 2018, 40(4):552-557.
FU X J, TANG A Q, MIN H, et al.Analysis on water phase state and transport in process of peanut seed soaking by using low-field nuclear magnetic resonance[J].Chinese Journal of Oil Crop Sciences, 2018, 40(4):552-557.
[19] 李定金, 段振华, 刘艳, 等.利用低场核磁共振技术研究调味山药片真空微波干燥过程中水分的变化规律[J].食品科学, 2019, 40(5):116-123.
LI D J, DUAN Z H, LIU Y, et al.Variation in water content during vacuum microwave drying of flavored yam chips process analyzed by low-field nuclear magnetic resonance imaging[J].Food Science, 2019, 40(5):116-123.
[20] 王雪媛, 高琨, 陈芹芹, 等.苹果片中短波红外干燥过程中水分扩散特性[J].农业工程学报, 2015(12):275-281.
WANG X Y, GAO K, CHEN Q Q, et al.Water diffusion characteristics of apple slices during short and medium-wave infrared drying[J].Transactions of the Chinese Society of Agricultural Engineering, 2015(12):275-281.
[21] LUV W Q, ZHANG M, BHANDARI B, et al.Smart NMR method of measurement of moisture content of vegetables during microwave vacuum drying[J].Food and Bioprocess Technology, 2017, 10(12):2 251-2 260.
[22] 任广跃, 曾凡莲, 段续, 等.利用低场核磁分析玉米干燥过程中内部水分变化[J].中国粮油学报, 2016, 31(8):95-99.
REN G Y, ZENG F L, DUAN X, et al.Analysis of internal moisture changes in corn dry process investigated by low field-NMR[J].Journal of the Chinese Cereals and Oils Association, 2016, 31(8):95-99.
[23] 卢映洁, 任广跃, 段续, 等.热风干燥过程中带壳鲜花生水分迁移特性及品质变化[J].食品科学, 2020, 41(7):86-92.
LU Y J, REN G Y, DUAN X, et al.Moisture migration properties and quality changes of fresh in-shell peanuts during hot air drying[J].Food Science, 2020, 41(7):86-92.
Options
文章导航

/

〈 〉

技术支持：北京玛格泰克科技发展有限公司