食品与发酵工业 >

2024 , Vol. 50 >Issue 3: 16 - 20

DOI: https://doi.org/10.13995/j.cnki.11-1802/ts.035180

研究报告

重组亚胺还原酶工程菌快速高密度发酵研究

  • 吴子蓥 ,
  • 李荣旭 ,
  • 白少钰 ,
  • 胡浩轩 ,
  • 黄佳俊 ,
  • 卢宇靖
展开
  • 1(佛山市汇腾生物技术有限公司,广东 佛山,528225)
    2(广东工业大学 生物医药学院,广东 广州,510006)
第一作者:硕士(卢宇靖教授为通信作者,E-mail:luyj@gdut.edu.cn)

收稿日期: 2023-02-20

  修回日期: 2023-04-03

  网络出版日期: 2024-03-15

基金资助

佛山市科技创新团队专项项目(1920001004116)

收起

Rapid high-density fermentation study on Escherichia coli recombinant strain for expressing imine reductase

  • WU Ziying ,
  • LI Rongxu ,
  • BAI Shaoyu ,
  • HU Haoxuan ,
  • HUANG Jiajun ,
  • LU Yujing
Expand
  • 1(TF BioSyn Biotechnology Company Limited, Foshan 528225, China)
    2(Guangdong University of Technology, Guangzhou 510006, China)

Received date: 2023-02-20

  Revised date: 2023-04-03

  Online published: 2024-03-15

Fold

摘要

通过快速高密度发酵培养,以重组亚胺还原酶大肠杆菌工程菌的菌体生物量及酶活力作为评价标准,利用低成本的发酵培养基,在短时间内获得菌体的最大生物量和最佳酶活力。采用2 L发酵体系,对该工程菌的接种量和诱导条件进行优化。结果表明,该菌株的快速高密度发酵最佳接种量为10%,当生物量OD600值达到12时,发酵体系降温至20 ℃,加入0.4 mmol/L 异丙基-β-D-硫代半乳糖苷,为最佳诱导条件,并以此条件进行20 L快速高密度发酵,诱导12 h酶活力最高,为4.56 U/g。该研究为进一步放大发酵体系以实现亚胺还原酶工业化快速高产量制备的生产奠定基础。

关键词： 亚胺还原酶; 大肠杆菌; 高密度发酵; 生物量; 酶活力

本文引用格式

吴子蓥 , 李荣旭 , 白少钰 , 胡浩轩 , 黄佳俊 , 卢宇靖 . 重组亚胺还原酶工程菌快速高密度发酵研究[J]. 食品与发酵工业, 2024 , 50(3) : 16 -20 . DOI: 10.13995/j.cnki.11-1802/ts.035180

Abstract

Rapid high-density fermentation was employed to obtain maximal biomass and enzyme activity of recombinant imine reductase-expressing Escherichia coli engineered strain using a low-cost fermentation medium as the culture medium. The bacterial biomass and enzyme activity were used as evaluation indicators. A 2 L fermentation system was used to optimize the inoculation amount and induction conditions for the engineered strain. The results showed that the optimal inoculation amount for the strain was 10%, and when the biomass OD600 reached 12, the fermentation system was cooled to 20 ℃, and 0.4 mmol/L isopropyl-beta-D-thiogalactoside (IPTG) was added as the best induction condition. Under this condition, a 20 L rapid high-density fermentation was performed, and the maximum enzyme activity was 4.56 U/g after induction for 12 h. This study lays the foundation for further scaling up the fermentation system to achieve rapid and high-yield production of imine reductase for industrial applications.

Key words： imine reductase; Escherichia coli; high density fermentation; biomass; enzyme activity

参考文献

[1] 曹文斌, 李昊, 陈飞飞, 等.亚胺还原酶的改造及其催化合成1-苯基-1, 2, 3, 4-四氢异喹啉的性能[J].华东理工大学学报(自然科学版), 2022, 48(4):511-518.
CAO W B, LI H, CHEN F F, et al.Modification and characterization of imine reductases for synthesis of 1-phenyl-1, 2, 3, 4-tetrahydro-isoquinoline[J].Journal of East China University of Science and Technology, 2022, 48(4):511-518.
[2] PATIL M D, GROGAN G, BOMMARIUS A, et al.Oxidoreductase-catalyzed synthesis of chiral amines[J].ACS Catalysis, 2018, 8(12):10985-11015.
[3] 李骥璇. 亚胺还原酶辅酶再生体系的构建及定点突变的研究[D].北京:清华大学, 2019.
LI J X.Co-expressed system construction and site-directed mutagenesis of imine reductase[D].Beijing:Tsinghua University, 2019.
[4] 杨璐, 瞿旭东.亚胺还原酶在手性胺合成中的应用[J].合成生物学, 2022, 3(3):516-529.
YANG L, QU X D.Application of imine reductase in the synthesis of chiral amines[J].Synthetic Biology Journal, 2022, 3(3):516-529.
[5] 程峰, 李清华, 李恒, 等.NAD(P)H依赖型氧化还原酶不对称还原胺化制备手性胺的研究进展[J].生物工程学报, 2020, 36(9):1794-1816.
CHENG F, LI Q H, LI H, et al.NAD(P)H-dependent oxidoreductases for synthesis of chiral amines by asymmetric reductive amination of ketones[J].Chinese Journal of Biotechnology, 2020, 36(9):1794-1816.
[6] GUO F, BERGLUND P.Transaminase biocatalysis:Optimization and application[J].Green Chemistry, 2017, 19(2):333-360.
[7] MATHEW S, YUN H.ω-transaminases for the production of optically pure amines and unnatural amino acids[J].ACS Catalysis, 2012, 2(6):993-1001.
[8] 刘国锋. 大肠杆菌高密度发酵产木聚糖酶发酵条件优化[J].中国酿造, 2017, 36(12):63-67.
LIU G F.Optimization of high density fermentation conditions of Escherichia coli for xylanase production[J].China Brewing, 2017, 36(12):63-67.
[9] 李娜, 杨江华, 韦宇拓.植物乳杆菌ZJ316高密度发酵条件优化[J].中国酿造, 2021, 40(5):43-48.
LI N, YANG J H, WEI Y T.Optimization of high-density fermentation conditions for Lactobacillus plantarum ZJ316[J].China Brewing, 2021, 40(5):43-48.
[10] 冀成法, 刘忠, 马鲁南, 等.重组大肠杆菌高密度、高表达研究进展[J].生物技术, 2022, 32(2):246-251.
JI C F, LIU Z, MA L N, et al.Review of high density fermentation and high expression of engineering E.coli[J].Biotechnology, 2022, 32(2):246-251.
[11] 沈加彬. 重组大肠杆菌产活性短肽高密度发酵研究[J].发酵科技通讯, 2022, 51(4):211-216.
SHEN J B.Study on high cell density cultivation in recombinant E.coli for production of active short chain polypeptide[J].Bulletin of Fermentation Science and Technology, 2022, 51(4):211-216.
[12] 刘开放, 席志文, 黄林娜, 等.布拉酵母高密度发酵培养基及发酵工艺优化[J].食品科学, 2019, 40(8):56-62.
LIU K F, XI Z W, HUANG L N, et al.Optimization of high cell density fermentation of Saccharomyces boulardii for enhanced biomass production[J].Food Science, 2019, 40(8):56-62.
[13] 王振东. 乳酸片球菌IMAU94388的高密度培养研究[D].内蒙古:内蒙古农业大学, 2020.
WANG Z D.Study on high cell density culture of Pediococcus acidilactici IMAU94388[D].Inner Mongolia:Inner Mongolia Agricultural University, 2020.
[14] PONTRELLI S, CHIU T Y, LAN E I, et al.Escherichia coli as a host for metabolic engineering[J].Metabolic Engineering, 2018, 50:16-46.
[15] DONG X B, TANG B, LI J, et al.Expression and purification of intact and functional soybean (Glycine max) seed ferritin complex in Escherichia coli[J].Journal of Microbiology and Biotechnology, 2008, 18(2):299-307.
[16] 徐冰, 马江锋, 梁丽亚, 等.基于高密度培养的反复分批发酵法生产丁二酸[J].化工学报, 2011, 62(9):2595-2599.
XU B, MA J F, LIANG L Y, et al.Succinic acid production by repeated batch fermentation based on high density culture[J].CIESC Journal, 2011, 62(9):2595-2599.
[17] NUC P, NUC K.Recombinant protein production in Escherichia coli[J].Postepy Biochemii, 2006, 52(4):448-456.
[18] 张震, 熊海波, 徐庆阳.大肠杆菌高密度培养发酵L-色氨酸[J].食品与发酵工业, 2019, 45(23):15-20.
ZHANG Z, XIONG H B, XU Q Y.L-tryptophan fermentation by high cell density culture of Escherichia coli[J].Food and Fermentation Industries, 2019, 45(23):15-20.
[19] 艾正文. 基于大肠杆菌表达系统制备β-酪蛋白研究[J].食品工业科技, 2023, 44(16):131-138.
AI Z W.Preparation of β-casein based on Escherichia coli expression system[J].Science and Technology of Food Industry, 2023, 44(16):131-138.
[20] 满在伟, 崔慧慧, 李锦, 等.谷氨酸棒杆菌表达大肠杆菌来源海藻糖酶[J].食品研究与开发, 2022, 43(24):181-187.
MAN Z W, CUI H H, LI J, et al.Expression of trehalase from Escherichia coli by Corynebacterium glutamicum[J].Food Research and Development, 2022, 43(24):181-187.
[21] 周卫强, 何太波, 唐堂, 等.工程大肠杆菌异源表达D-阿洛酮糖3-差向异构酶的诱导工艺研究[J].发酵科技通讯, 2019, 48(4):192-196.
ZHOU W Q, HE T B, TANG T, et al.Study of induction process for heterologous expression of D-psicose 3-epimerasein engineering Escherichia coli[J].Bulletin of Fermentation Science and Technology, 2019, 48(4):192-196.
[22] 叶姣, 陈长华, 夏杰, 等.温度对重组大肠杆菌生长及外源蛋白表达的影响[J].华东理工大学学报, 2002, 28(4):364-367.
YE J, CHEN C H, XIA J, et al.Effect of temperature on the growth of recombinant E.coli and on the expression of recombinant protein[J].Journal of East China University of Science and Technology, 2002, 28(4):364-367.
[23] 赵翔, 钟浩, 孙超, 等.表达NADP+型甲酸脱氢酶重组大肠杆菌的高密度发酵研究[J].发酵科技通讯, 2020, 49(2):72-75.
ZHAO X, ZHONG H, SUN C, et al.Study on high density fermentation of recombinant Escherichia coli expressing NADP+-dependent formate dehydrogenase[J].Bulletin of Fermentation Science and Technology, 2020, 49(2):72-75.
[24] 张丽, 应向贤, 毛王伟, 等.裂殖酵母醛酮还原酶基因的克隆与诱导表达条件优化[J].发酵科技通讯, 2018, 47(3):161-165.
ZHANG L, YING X X, MAO W W, et al.Cloning, over-expression and optimization of induction conditions of an aldo-keto reductase from Schizosaccharomyces pombe[J].Bulletin of Fermentation Science and Technology, 2018, 47(3):161-165.
[25] 陈阿娜, 叶生梅, 孟娜, 等.外源蛋白在大肠杆菌中高效可溶性表达和胞外分泌策略研究综述[J].安徽农学通报, 2015, 21(13):25-27.
CHEN A N, YE S M, MENG N, et al.Advances of soluble and extracellular overexpression of heterologous proteins in Escherichia coli[J].Anhui Agricultural Science Bulletin, 2015, 21(13):25-27.
[26] 杨璐, 邓子新, 瞿旭东.亚胺还原酶(IRED)制备手性胺的研究进展[J].南京工业大学学报(自然科学版), 2019, 41(6):807-814.
YANG L, DENG Z X, QU X D.Progress in the preparation of chiral amines by imine reductase (IRED)[J].Journal of Nanjing Tech University (Natural Science Edition), 2019, 41(6):807-814.
[27] 李骥璇, 余磊, 李京美, 等.S-亚胺还原酶和葡萄糖脱氢酶共表达系统的构建及手性胺的合成[J].生物技术通报, 2019, 35(1):105-111.
LI J X, YU L, LI J M, et al.Construction of co-expression system of S-imine reductase and glucose dehydrogenase and synthesis of chiral amine[J].Biotechnology Bulletin, 2019, 35(1):105-111.
Options
文章导航

/

〈 〉

技术支持：北京玛格泰克科技发展有限公司